Double-hung Windows
A double-hung window consists of two sashes: an upper, outside sash that moves down and a lower, inside one that moves up. A pulley and weight sys-tem or balances located in the jambs control the movement of the sashes. Double-hung windows may be made from wood, aluminum, or vinyl.
As a wood window sash ages, it may begin to misfit its frame, or the system controlling sash movement may break down. Some common window problems and their solutions are discussed below. Instructions for removing wood sashes and replacing a window’s balance system appear.
Metal and vinyl windows seldom require repairs. To keep them oper-ating smoothly occasionally clean the channels with very fine steel wool and coat them with silicone spray
A Double-hung Windows
Correcting ill-fitting sashes
Wood double-hung window sashes that don’t fit or don’t move correctly are annoying. Often, a simple sash or stop repair can restore the window to good working order. If none of the simple re-pairs described below works, you’ll need to remove and reposition the
stops (see facing page).
Freeing a stuck sash. If a sash is temporarily stuck because moisture has swelled the wood, a change of weather may correct it. For a sash that’s paint-bound, use one of the
methods shown on the facing page.
Freeing a tight sash. If a sash moves reluctantly the sash channels may need to be cleaned and lubricated or even widened (see facing page). If the sash itself is too wide, you may
need to sand it down or, in severe cases, plane it.
Correcting a loose sash. A sash that rattles and lets in unwanted air is too loose. Often, installing spring-type weatherstripping can correct the prob-lem.
If the gap isn’t too wide and the stop is nailed rather than screwed, you can move the stop slightly without actu-ally removing it. Score the paint be-tween the stop and jamb and place a cardboard shim between the stop and sash. Holding a block of wood against the stop to protect it, hammer toward the sash along the length of the stop until the paint breaks and the stop rests against the shim. Secure the stop with finishing nails.
If you need to remove and re-position the stop to correct a wide gap, see the instructions on the facing page. Tightening sash joints. If a sash’s joints are loose, you’ll have to remove the sash from the frame. Clean the joints; then repair the frame as shown.
Repairing window balance systems
If a sash refuses to remain open or closed, or if it jams in one position, repair or replace the balance system. Your windows may have a traditional weight and pulley balance system like that shown above, or a more modern spiral-lift, tension-spring, or cord balance system. Instructions for repairing and replacing balances appear.
Three Ways To Free A Paint-Bound Sash



Three Ways To Loosen A Tight Sash



Epositioning The Stops



Broken Balance Systems
When a window’s balance system is broken, the window will not remain open or closed. The repair depends on the type of system-pulley and weight, spiral-lift, tension-spring, or cord -
used in the window.
To repair or replace a balance system, you’ll have to remove one or both sashes (see below). If just the lower sash is affected, remove only that one. If the repair involves the upper sash, remove both. Be sure to take off any interlocking weatherstripping before
removing the sash.
Pulley & weight system
Pulleys and weights traditionally operate double-hung windows. The weights are suspended on cords or chains located behind the side jambs. If you’re replacing a broken cord, it’s a good idea to replace all the cords in the window at the same time, preferably with long-lasting chains, as shown below. To replace a defective chain, fol-low the instructions for cords. Before detaching the old chain, be sure to im-mobilize the weights on each side by drawing up the chains until the weights touch the pulleys. Slide a nail through a link at each pulley to hold the chains in place; then detach the chains from the sash. Once the new chains are in place, replace the upper sash, parting strips, access plates, bottom sash, and stops, in that order, checking the operation of each sash as you go.
Removing Wood Sashes & Replacing Cords






Spiral-lift system
In a spiral-lift balance system, a spring-loaded spiral rod encased in a tube rests in a channel in the side of the stile. The top of the tube is screwed to the side jamb; the rod is attached to a mounting bracket on the bottom of the sash (see illustration below). Each sash has two such units.
Adjusting the tension. With a spiral-lift balance, adjusting the spring tension may be all that’s needed to make the window operate properly If the sash tends to creep up, loosen the spring by detaching the tube from the sash channel and letting the spring unwind a bit. If the sash keeps sliding down, turn the rod clockwise a few times to tighten the spring. If this doesn’t help, you’ll need to replace the unit.
Replacing the unit. To remove a broken balance, pry off the stop on the affected side (page 55) and unscrew the tube where it’s fastened to the top of the side jamb. Let the spring unwind; then raise the sash 6 to 8 inches and angle it out of the frame. If the rod is
attached to the bottom of the sash with a detachable hook, unhook it; support the sash in a raised position with a wood block, and unscrew and remove the mounting bracket.
Position a new tube in the channel and screw it into the top of the side jamb. Pull the spiral rod down as far as it will go and turn it clockwise about four complete turns to tighten the spring. Let the rod retract into the tube far enough so you can fasten the mounting bracket to the bottom of the sash. Replace the sash.
Check the movement of the sash by sliding it up and down, and adjust the tension as described at left. Once the window is operating properly reposition the stop (page 55).
Tension-spring & cord systems
In a tension-spring balance system, each sash is operated by two balance units with spring-loaded drums inside; the units fit into the side jamb near the top. A flexible metal tape hooks onto a bracket screwed into a groove in the sash.
A cord balance system, not shown here, is a variation of the tension-spring system. Two spring-loaded reel units fit into each corner of the top jamb. Nylon cords connect the units to each sash; plastic top and side jamb liners conceal the working parts.
Replacing the unit. If any part of a tension-spring or cord balance system breaks, you’ll have to remove the unit and install a new one.
To remove a tension-spring unit, remove the stop on the affected side (page 55) and ease out the sash. Un-hook the tape from the bracket and let it wind back on the drum. Remove the screws from the drum plate and pry the unit out of the jamb pocket.
Insert the new balance into the jamb pocket and secure it with wood screws. Using needlenose pliers, pull the tape down and hook the end to the bracket on the sash. Replace the sash, check its operation, and reposition the stop (page 55).
A cord balance unit is replaced in the same way as a tension-spring unit. You’ll need to remove the jamb liners in order to remove the sash and then pry out the balance unit from the top jamb.
Replacing A Spiral-Life Unit

Replacing A Tension-Spring Unit










































(1.2.14)






















